What to look for when buying a Ford Mondeo 2000 - 2007, covering common problems to check for and overall vehicle reliability. Some problems with injectors on the TDCi engines have been Hello everyone. I recently joined your club :) and bought a ford fiesta 1.4 tdci 2007. I have noticed that the engine is shaking around 1000-1500 rpms. I suspected an injector is at fault. I did a comp reading and it showed that there was something wrong with the second injector. I did a Diesel purge with liqui moly additive, but there was no I'm not so much of a cars person, but hey, problem is a problem. So, I've bought 6 months ago Ford Mondeo Estate 2010 120kw/161bhp with 193 000 km on dash. About a month ago, I had troubles to get it started, It starts for a second and then instantly dies. I don't know how many posts I've already read, mainly stating that is a EGR problem. When we first drove the new (well, kind of new) Ford Mondeo at launch, this was the missing link in the engine line-up – the range-topping, twin-turbocharged 207bhp 2.0-litre Duratorq TDCi. It Report of turbo oil-seal failure in 2.2 TDCi turbo caused engine to run on its sump oil and self-destruct. Bill for replacement engine, turbo, catalytic converter, exceeded £7,000. Diff problem starting to crop up on TDCI 130 6-speeds at around 3 years old, so any vibrations just before the warranty ends, make sure you notify the supplying . Ford Mondeo 2.0 TDCI Engine Problems & Maintenance; Ford F-150 Clicking Noise When Starting; Exhaust Fluid System Fault F250: Top 2 Causes; Ford F-150 Transmission Problems: Causes & Repairs; 3 Ford Explorer Transmission Problems You Should Know; Ford Escort Transmission Problems: Causes & Fixes; Ford Mustang Transmission Problems: 5 Symptoms I have the following problem with my Mondeo: ONLY and ONLY in 2nd gear when driving at constant speed the car accelerates by itself for 1 or 2 seconds every 3 or 4 seconds. So it is absolutely impossible to drive it with constant speed in the second gear. The car has absolutely no problem in 1st, 3rd, 4th, 5th or 6th gear. Tue 10 May 2011 23:01. 2.0 tdci - tdci engine cuts out - R2-CMax. Could be the EGR valve jamming open - particularly if it happens when you're trying to accelarate - very hot exhaust gas is pulled back into the front of the engine, so the engine goes into self-preservation mode to avoid something getting fried.

ford mondeo 2.0 tdci engine problems